Search results

Ok so I have a 2004 Sportsman 600 twin and I have oil coming out above my manifold which i guess would be the rocker cover seal. Anyone know how hard it is to change this seal? can I take the bolts out and lift the cover up and place the new one in?' thanks

I thought my belt housing had 2 pipes coming off of it, one that runs straight up and on that runs along side the gas tank.

Anyone out there know what I can use for the front drive shafts u-joint other than Polaris? 2004 Sportsman 600 twin Thanks :cool:

Front diff lock?? All I have to do is flick a switch and its in awd. I changed the spark plugs tonight and after I took out the 2nd ngk I fired it up and it even sounded better. I took it down to the quarry and drove the heck out of it in the water to the point I was soaked, but I was still...

Just took it out again and it seems to be running fine. I need some water to test it!

2004 Sportsman 600 twin. I have to say Im new to atvs and all this but it does seem elec to me. It ran great till it this mud hole and I though it was the tailpipe going under and thats why it died, but once I got out it was still acting up. I took it out last night about 6 hours after I got...

Air filter is bone dry, the carb boots are good, I checked the plugs and they seem fine. The plug boots were a little dirty so I cleaned them up and put the die elec to them. Just odd that when I hit a little bit of water or mud, well most of the time deep mud it dies on me.

Ok so today I hit this mud hole and then water hole at low speeds and the bike started to spit and sputter and then it died on me and after that when I gave it some throttle it would get to about 25 mph and start to spit and sputter and wouldn't go faster. I can cruise along at a good speed but...

Whats the best way to drain the tank?

Ok so I just looked in my gas tank and I see dirt at the bottom of the tank. It doesn't looking like a a lot but its still there. Should I drain the tank out and if so how? or will the fuel filter catch this dirt?? Thanks

Very nice, thanks so much that was what I was looking for!!!:d Is there a loop in the line b4 I feed it down??

Can anyone out there tell me where their gas tank vent line runs to? I had to replace mine as it rotted and broke the dealership told me to run down the frame to the back of the bike and onto the ground, I did that and the first mud hole I got buried in the mud and water came right up the tube...